Research on Alkali-free Flotation Separation of Lead and Zinc in a Polymetallic Sulfide Mine
-
摘要:
针对广西某铅锑锌多金属硫化矿石进行了弱磁选—铅锑优先浮选工艺研究。闭路试验结果表明,采用该工艺对该铅锑锌多金属硫化矿石进行选别,在原矿含Pb 2.27%、Sb 1.98%、Zn 13.43%情况下,获得了含Pb 27.61%、Sb 23.76%、Zn 5.47%的铅锑精矿,铅回收率89.09%,锑回收率88.78%。与丁铵黑药药剂制度指标相比,铅锑精矿的铅锑品位分别提高了2.1和0.95个百分点,Pb和Sb回收率分别提高了2.76和3.65个百分点,锌回收率降低了1.57个百分点。与现场药剂制度指标相比,铅锑精矿铅锑品位分别提高了1.56和0.45个百分点,Pb和Sb回收率分别提高了2.85和2.61个百分点,锌回收率降低了1.14个百分点。
Abstract:Through the combination of weak magnetic separation and lead-antimony flotation in a lead-antimony-zinc polymetallic sulfide mine in Guangxi, excellent flotation indexes were obtained. To deal with the complex lead-antimony-zinc sulfide ore containing Pb 2.28 %, Sb 1.98 %, Zn 13.43%, closed-circuit tests indicated that was conducted, lead grade and recovery were 27.61% and 89.09%, respectively, and antimony grade and recovery were 23.76% and 88.78%, respectively, in lead-antimony concentrate with 5.47% zinc. Compared with the flotation indexes with ammonium dibutyl dithiophosphate, the grade of lead(Pb) and antimony(Sb) have increased by 2.10% and 0.95% respectively, while the recovery of Pb and Sb have increased by 2.76% and 3.65% respectively, zinc recovery rate reduced by 1.57%. Compared with the flotation indexes on-site process, the grade of lead(Pb) and antimony(Sb) have increased by 1.56% and 0.45% respectively, while the recovery of Pb and Sb have increased by 2.85% and 2.61% respectively, zinc recovery rate reduced by 1.14%.
-
-
表 1 矿石的主要化学成分分析结果
Table 1. Main chemical composition analysis result of ore samples
/% 组分 Pb Zn Sn Sb Fe As Al2O3 CaO 含量 2.27 13.43 1.29 1.98 35.44 0.76 0.37 5.62 组分 Cu SiO2 MgO K2O Na2O S P C 含量 0.067 2.35 0.48 0.14 0.022 29.00 0.17 3.29 表 2 矿石铅、锑和锌物相分析结果
Table 2. Phase analysis results of lead, antimony and zinc in ore
/% 物相 铅 锑 锌 含量 分布率 含量 分布率 含量 分布率 硫化物 1.98 86.84 1.67 85.20 12.03 89.37 氧化物 0.19 8.33 0.23 11.73 0.13 0.97 其它 0.11 4.83 0.06 3.07 1.30 9.66 合计 2.28 100.00 1.96 100.00 13.46 100.00 表 3 矿石矿物组成分析结果
Table 3. Mineral composition analysis results of ore samples
/% 矿 物 脆硫锑铅矿 铁闪锌矿 磁黄铁矿 锡石 黄铁矿 菱铁矿 含 量 7.0 24.6 30.9 1.8 15.5 2.1 矿 物 毒砂 方解石 石英 云母 其它 含 量 1.6 11.5 2.3 1.9 0.8 表 4 磨矿产品中各矿物的解离度
Table 4. Dissociation degree of minerals in grinding products
/% 矿物名称 单体 ≥3/4 3/4~1/2 1/2~1/4 ≤1/4 总和 脆硫锑铅矿 90.3 4.3 3.0 1.4 1.0 100.0 铁闪锌矿 91.6 3.2 2.5 1.6 1.1 100.0 锡石 93.3 3.4 0.6 1.7 1.0 100.0 表 5 磁选试验结果
Table 5. Results of magnetic separation test
/% 磁感应强度/T 产品名称 产率 品位 回收率 Pb Zn Sn Pb Zn Sn 0.142 磁选精矿 12.96 0.23 0.68 0.12 1.32 0.65 1.22 磁选尾矿 87.04 2.56 15.36 1.45 98.68 99.35 98.78 合计 100.00 2.26 13.46 1.28 100.00 100.00 100.00 0.151 磁选精矿 13.01 0.24 0.66 0.14 1.37 0.64 1.41 磁选尾矿 86.99 2.58 15.39 1.46 98.63 99.36 98.59 合计 100.00 2.28 13.47 1.29 100.00 100.00 100.00 表 6 铅锑粗选不同捕收剂试验结果
Table 6. Results of lead-antimony bulk rough flotation with different collectors
药剂制度 品位/% 回收率/% Pb Zn Pb Zn 丁铵黑药+苯胺黑药 29.32 8.53 79.86 4.35 丁铵黑药 29.51 8.11 80.65 4.29 25#黑药+CSU11 30.90 6.38 81.96 2.89 表 7 铅锑粗选硫酸用量试验结果
Table 7. Results of lead-antimony mixed rough concentrate on dosage of sulfuric acid
药剂用量/(g·t-1) 产品名称 产率/% 品位/% 回收率/% 硫酸 ZnSO4 CSU61 Pb Zn Pb Zn 300 500 500 磁选精矿 12.97 0.24 0.75 1.36 0.72 铅锑精矿 7.85 24.53 9.17 84.41 5.35 铅尾 79.18 0.410 15.96 14.23 93.93 原矿 100.00 2.281 13.45 100.00 100.00 500 500 500 磁选精矿 12.95 0.23 0.73 1.30 0.70 铅锑精矿 8.81 23.21 9.28 89.06 6.08 铅尾 78.24 0.283 16.03 9.64 93.22 原矿 100.00 2.296 13.45 100.00 100.00 700 500 500 磁选精矿 12.97 0.23 0.75 1.31 0.72 铅锑精矿 8.90 22.78 9.32 89.08 6.18 铅尾 78.13 0.280 16.00 9.61 93.10 原矿 100.00 2.276 13.43 100.00 100.00 900 500 500 磁选精矿 12.96 0.25 0.74 1.42 0.71 铅锑精矿 9.11 22.53 9.97 89.73 6.76 铅尾 77.93 0.260 15.96 8.86 92.53 原矿 100.00 2.288 13.44 100.00 100.00 表 8 铅锑粗选调整剂硫酸锌和CSU61用量试验结果
Table 8. Results of lead and stibium mixed rough concentrate on dosage of Zinc sulfate and CSU61
药剂用量/(g·t-1) 产品名称 产率/% 品位/% 回收率/% 硫酸 ZnSO4 CSU61 Pb Zn Pb Zn 500 0 500 磁选精矿 12.93 0.24 0.72 1.36 0.69 铅粗精矿 8.86 23.00 9.57 89.07 6.31 铅尾 78.21 0.280 15.98 9.57 93.00 原矿 100.00 2.288 13.44 100.00 100.00 500 500 500 磁选精矿 12.95 0.23 0.73 1.30 0.70 铅粗精矿 8.81 23.21 9.28 89.06 6.08 铅尾 78.24 0.283 16.03 9.64 93.22 原矿 100.00 2.296 13.45 100.00 100.00 500 800 800 磁选精矿 12.93 0.23 0.71 1.31 0.68 铅粗精矿 8.76 23.10 9.24 89.14 6.01 铅尾 78.31 0.277 16.05 9.55 93.31 原矿 100.00 2.270 13.47 100.00 100.00 500 800 0 磁选精矿 12.94 0.25 0.73 1.43 0.70 铅粗精矿 8.92 22.56 10.22 89.03 6.78 铅尾 78.14 0.276 15.91 9.54 92.51 原矿 100.00 2.260 13.44 100.00 100.00 500 500 800 磁选精矿 12.96 0.23 0.75 1.32 0.72 铅粗精矿 8.67 23.10 9.00 88.44 5.79 铅尾 78.37 0.296 16.07 10.24 93.49 原矿 100.00 2.265 13.47 100.00 100.00 表 9 不同捕收剂条件下闭路试验结果
Table 9. Results of closed-circuit test ondifferent collectors
药剂制度 产品名称 产率/% 品位/% 回收率/% Pb Sb Zn Pb Sb Zn 丁铵黑药+苯胺黑药 磁选精矿 12.97 0.26 0.25 0.73 1.40 1.50 0.70 铅锑精矿 7.99 26.05 23.31 7.01 86.24 86.17 4.13 铅尾 79.04 0.38 0.34 16.33 12.36 12.33 95.17 原矿 100.00 2.41 2.16 13.56 100.00 100.00 100.00 丁铵黑药 磁选精矿 12.93 0.25 0.23 0.75 1.33 1.35 0.73 铅锑精矿 8.23 25.51 22.81 7.32 86.33 85.13 4.56 铅尾 78.84 0.38 0.38 15.87 12.34 1.47 0.68 原矿 100 2.43 2.21 13.21 100.00 100.00 100.00 25#黑药+CSU11 磁选精矿 12.95 0.24 0.23 0.73 1.33 1.48 0.68 铅锑精矿 7.56 27.61 23.76 5.47 89.09 88.78 2.99 铅尾 79.49 0.28 0.25 16.76 9.58 9.74 96.33 原矿 100.00 2.34 2.02 13.83 100.00 100.00 100.00 -
[1] 邹光旭, 吴雪兰, 郭争争, 等. 铅锌矿铅锌浮选的研究进展[J]. 安徽化工, 2017, 43(3): 13-18. https://www.cnki.com.cn/Article/CJFDTOTAL-AHHG201703004.htm
[2] 丁声强. 铅锌硫化矿低碱分离技术研究[D]. 赣州: 江西理工大学, 2013.
[3] 戴晶平, 刘侦德. 铅锌选矿技术[M]. 长沙: 中南大学出版社, 2010: 1-2.
[4] 刘斌, 叶茜. 铅锌矿石浮选分离抑制剂研究进展[J]. 有色矿冶, 2014, 30(4): 33-36. https://www.cnki.com.cn/Article/CJFDTOTAL-YSKY201404010.htm
[5] 丁声强, 邱廷省, 张宝红, 等. 某含银多金属硫化矿选矿试验研究[J]. 有色金属科学与工程, 2013, 4(1): 72-78. https://www.cnki.com.cn/Article/CJFDTOTAL-JXYS201301017.htm
[6] 刘润清, 孙伟, 胡岳华, 等. 巯基类小分子有机抑制剂对复杂硫化矿物浮选行为的抑制机理[J]. 中国有色金属学报, 2006(4): 746-751. https://www.cnki.com.cn/Article/CJFDTOTAL-ZYXZ200604030.htm
[7] 周德炎. 单宁类有机抑制剂对长坡选矿厂全浮硫化矿铅锌分离试验研究[J]. 大众科技, 2012(1): 111-113. https://www.cnki.com.cn/Article/CJFDTOTAL-DZJI201201046.htm
[8] 陈建华, 梁梅莲, 蓝丽红. 偶氮类有机抑制剂对硫化矿的抑制性能[J]. 中国有色金属学报, 2010, 20(11): 2239-2247. https://www.cnki.com.cn/Article/CJFDTOTAL-ZYXZ201011029.htm
[9] 吴伯增. 大厂贫锡多金属硫化矿选矿关键技术研究及应用[D]. 长沙: 中南大学, 2005.
[10] 黎全. 大厂100(105)号锡石多金属矿选矿关键技术研究及应用[D]. 长沙: 中南大学, 2007.
[11] 吴世发. 大厂贫锡铅锑锌多金属硫化矿浮选新技术研究[D]. 长沙: 中南大学, 2010.
[12] 朱宾, 陆智, 蔡振波. 用新型捕收剂回收某铅锑锌锡多金属矿石中的铅锑[J]. 金属矿山, 2013(2): 81-85. https://www.cnki.com.cn/Article/CJFDTOTAL-JSKS201302021.htm
[13] 胡明振, 曾纪术, 陈锦全, 等. 广西大厂贫铟锡多金属硫化矿石中铅锑的浮选试验[J]. 金属矿山, 2016, (1): 85-88. https://www.cnki.com.cn/Article/CJFDTOTAL-JSKS201601020.htm
[14] 彭学天. 大厂铅锑精矿降锌试验[J]. 现代矿业, 2019, 35(7): 193-194. https://www.cnki.com.cn/Article/CJFDTOTAL-KYKB201907056.htm
[15] 陈雄. 铅锑锌硫化矿清洁生产技术的基础研究及应用[D]. 长沙: 中南大学, 2018.
-